欢迎进入济南济柴环能燃气发电设备有限公司官网!

常见问题解答

瓦斯发电机组开关机注意事项

返回 2020.12.18 来源:http://www.huannengpower.com
一、启动前检查
1、 Pre start check
1、检查柴油发电机组机油油位是否在标示刻度线以内,不够加同型号机油至标示线以内。
1. Check whether the oil level of the diesel generator set is within the marked mark, and it is not enough to add the same type of oil to the marked line.
2、检查冷却液是否在水箱盖以下6mm左右,不够加清水至上述位置。
2. Check whether the coolant is about 6mm below the water tank cover, and it is not enough to add water to the above position.
3、检查电解液液位是否在极板面上15mm左右,不够加蒸馏水至上述位置。
3. Check whether the electrolyte level is about 15mm above the plate surface, and it is not enough to add distilled water to the above position.
4、检查发电机周围,把有碍操作或运行的物品搬开,使得通风通畅。
4. Check around the generator and remove the objects that hinder the operation or operation to make the ventilation unobstructed.
5、使得柴油发电机组总开关在OFF(关)状态。
5. Make the main switch of diesel generator set in off state.
6、使得燃油箱油量在一半以上,燃油供油阀常开。
6. Make the fuel tank more than half of the fuel volume, the fuel supply valve is always open.
二、启动
2、 Start
1、使得控制屏上各按钮已经复位,将速度操作手柄调到怠速位置
1. Make the buttons on the control panel have been reset, and adjust the speed operating handle to the idle position
瓦斯发电机组
2、把钥匙转到开的位置,按下启动按钮柴油发电机启动。
2. Turn the key to the on position and press the start button to start the diesel generator.
3、将速度调节手柄慢慢上调直至电压为400V;频率、50赫芝时拧紧固定手柄螺母,发电机正常运行。
3. Slowly raise the speed regulating handle until the voltage is 400V; when the frequency is 50 Hz, tighten the fixed handle nut, and the generator operates normally.
4、柴油发电机正常情况下,一次启动着车或三次启动着车,如果柴油发电机组三次不能启动着车,控制面板上的故障指示灯亮,此时应查明原因并排除故障再启动。
4. Under normal conditions, the diesel generator is started once or three times. If the diesel generator set fails to start for three times, the fault indicator light on the control panel will be on. At this time, the cause shall be found out and the fault shall be eliminated before starting.
5、启动着车后应检查有无噪音或震动,有无漏油,有无漏水,漏气现象,控制屏有无异常显示,在开机10~15秒内油压应达到正常范围((35~60p.s.i)如有不正常情况应做出相应的整改,待正常后合上发电机总开关开始供电。
5. After starting the vehicle, check whether there is noise or vibration, oil leakage, water leakage and air leakage, and whether there is abnormal display on the control panel. The oil pressure should reach the normal range ((35 ~ 60p. S.I) within 10 ~ 15 seconds after starting the vehicle. If there is any abnormal situation, corresponding rectification should be made. After normal operation, the main switch of the generator should be closed to start power supply.
三、停机
3、 Shutdown
1、先扳下发电机总开关,让发电机空载运行5分钟,然后把调速手柄扳到怠速位置运行5分钟再扳到STOP的位置,柴油发电机停机。
1. First pull down the main switch of the generator, let the generator run for 5 minutes without load, then turn the speed control handle to the idle position for 5 minutes, and then turn it to the stop position to stop the diesel generator.
2、如有紧急情况需停车,可以不扳下发电机总开关直接将调速手柄扳到的位置柴油发电机停机。
2. If it is necessary to stop in case of emergency, the diesel generator can be shut down by pulling the speed regulating handle to the position where the master switch of generator is not pulled.
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

瓦斯发电机组开关机注意事项

一、启动前检查
1、 Pre start check
1、检查柴油发电机组机油油位是否在标示刻度线以内,不够加同型号机油至标示线以内。
1. Check whether the oil level of the diesel generator set is within the marked mark, and it is not enough to add the same type of oil to the marked line.
2、检查冷却液是否在水箱盖以下6mm左右,不够加清水至上述位置。
2. Check whether the coolant is about 6mm below the water tank cover, and it is not enough to add water to the above position.
3、检查电解液液位是否在极板面上15mm左右,不够加蒸馏水至上述位置。
3. Check whether the electrolyte level is about 15mm above the plate surface, and it is not enough to add distilled water to the above position.
4、检查发电机周围,把有碍操作或运行的物品搬开,使得通风通畅。
4. Check around the generator and remove the objects that hinder the operation or operation to make the ventilation unobstructed.
5、使得柴油发电机组总开关在OFF(关)状态。
5. Make the main switch of diesel generator set in off state.
6、使得燃油箱油量在一半以上,燃油供油阀常开。
6. Make the fuel tank more than half of the fuel volume, the fuel supply valve is always open.
二、启动
2、 Start
1、使得控制屏上各按钮已经复位,将速度操作手柄调到怠速位置
1. Make the buttons on the control panel have been reset, and adjust the speed operating handle to the idle position
瓦斯发电机组
2、把钥匙转到开的位置,按下启动按钮柴油发电机启动。
2. Turn the key to the on position and press the start button to start the diesel generator.
3、将速度调节手柄慢慢上调直至电压为400V;频率、50赫芝时拧紧固定手柄螺母,发电机正常运行。
3. Slowly raise the speed regulating handle until the voltage is 400V; when the frequency is 50 Hz, tighten the fixed handle nut, and the generator operates normally.
4、柴油发电机正常情况下,一次启动着车或三次启动着车,如果柴油发电机组三次不能启动着车,控制面板上的故障指示灯亮,此时应查明原因并排除故障再启动。
4. Under normal conditions, the diesel generator is started once or three times. If the diesel generator set fails to start for three times, the fault indicator light on the control panel will be on. At this time, the cause shall be found out and the fault shall be eliminated before starting.
5、启动着车后应检查有无噪音或震动,有无漏油,有无漏水,漏气现象,控制屏有无异常显示,在开机10~15秒内油压应达到正常范围((35~60p.s.i)如有不正常情况应做出相应的整改,待正常后合上发电机总开关开始供电。
5. After starting the vehicle, check whether there is noise or vibration, oil leakage, water leakage and air leakage, and whether there is abnormal display on the control panel. The oil pressure should reach the normal range ((35 ~ 60p. S.I) within 10 ~ 15 seconds after starting the vehicle. If there is any abnormal situation, corresponding rectification should be made. After normal operation, the main switch of the generator should be closed to start power supply.
三、停机
3、 Shutdown
1、先扳下发电机总开关,让发电机空载运行5分钟,然后把调速手柄扳到怠速位置运行5分钟再扳到STOP的位置,柴油发电机停机。
1. First pull down the main switch of the generator, let the generator run for 5 minutes without load, then turn the speed control handle to the idle position for 5 minutes, and then turn it to the stop position to stop the diesel generator.
2、如有紧急情况需停车,可以不扳下发电机总开关直接将调速手柄扳到的位置柴油发电机停机。
2. If it is necessary to stop in case of emergency, the diesel generator can be shut down by pulling the speed regulating handle to the position where the master switch of generator is not pulled.