Gas generator sets have high requirements for operation environment and supporting equipment. If not handled properly, it is easy to cause disaster. In addition to the following regulations, the operating procedures shall be formulated and strictly followed according to the specific conditions when using gas generator set. Let's see what we should pay attention to when we use gas generator set!

　　一、机房设置要合理

　　1、 Reasonable setting of machine room

　　1.机房一般采用开式或半开式，地面应平整，便于清洁。

　　1. The machine room is generally open or semi open, and the ground shall be flat and easy to clean.

　　2.封闭式机房应按防爆要求设计。它应该是一座所有门窗都开着的单层建筑。

　　2. The enclosed machine room shall be designed according to the explosion-proof requirements. It should be a single story building with all the doors and windows open.

　　3.机房和操作室要分开。观察窗为双层玻璃，用钢丝网保护。

　　3. the machine room and operation room shall be separated. The observation window is double-layer glass, protected by steel wire mesh.

　　4.机房应设有防雷装置。

　　4. The machine room shall be equipped with lightning protection device.

　　5.燃气发电机组运行现场不得有明火，不得设置“禁止燃放烟花爆竹”等警示标志。

　　5. There shall be no open fire and warning signs such as "no fireworks and firecrackers".

　　6.足够的消防设备。

　　6. Sufficient fire fighting equipment.

　　7.将发动机排气系统的废气与可燃气体混合，从发动机设计安装到室外排气管系统。

　　7. Mix exhaust gas of engine exhaust system with combustible gas, and install it from engine design to outdoor exhaust pipe system.

　　二、燃气发电机组及配套设备应符合标准要求

　　2、 Gas generator unit and supporting equipment shall meet the standard requirements

　　1.燃气发电机组机房电气设施应防爆，检修时应切断电源。

　　1. The electrical facilities in the gas generator room shall be explosion-proof, and the power supply shall be cut off during maintenance.

　　2.设置应急阀，在车间发生紧急情况时切断气源。阀门应该靠近手术室。

　　2. Set emergency valve to cut off the air source in case of emergency in the workshop. The valve should be close to the operating room.

　　3.气体发生器室应安装气体浓度报警器。

　　3. A gas concentration alarm shall be installed in the gas generator room.

　　三、燃气管道应当达到规定的标准，并及时修复

　　3、 The gas pipeline shall meet the specified standards and be repaired in time

　　1.燃气管道采用厚壁钢管，接头密封良好。

　　1. The gas pipeline adopts thick wall steel pipe, and the joint is well sealed.

　　2.定期检查阀门，及时维修或更换阀门。

　　2. Check the valve regularly and repair or replace the valve in time.

　　3.燃气管道上的胶管应定期更换，禁止老化胶管。

　　3. The rubber hose on the gas pipeline shall be replaced regularly, and aging rubber hose is prohibited.

　　4.燃气发电机组及输气管道维修期间，应切断气源，排尽气体。在查明事故原因并采取相应措施之前，不得将燃气恢复到燃气设施。维修时应采取防爆措施或使用防爆工具。严禁用铁器敲打。

　　4. During the maintenance of gas generator unit and gas transmission pipeline, cut off the air source and exhaust the gas. Before finding out the cause of the accident and taking corresponding measures, the gas shall not be restored to the gas facilities. Explosion proof measures shall be taken or explosion-proof tools shall be used during maintenance. It is forbidden to knock with iron.

　　燃气发电机组在使用过程中需要更加注意严格按照规章制度操作。在燃气发电机组的选择上要选择合格的厂家，这样才能保证产品的质量。

　　In the process of using the gas generator set, more attention should be paid to operating in strict accordance with the rules and regulations. In the selection of gas-fired generator units, qualified manufacturers should be selected, so as to ensure the quality of products.