欢迎进入济南济柴环能燃气发电设备有限公司官网!
当前位置:首页 - 新闻中心 - 发电机知识

发电机知识

延长柴油发电机长寿秘诀有哪些?

返回 2022.01.18 来源:http://www.huannengpower.com
1、用:即正确使用柴油发电机。起动前,应先摇车,使各轴瓦等润滑部位得到润滑油后再起动。起动后,应待水温达到40-50℃时,再投人作业。严禁长时间超负荷或低速作业。停机前,应先卸掉负荷,降低转速。冬季停车后,应待水温下降至40-50℃时,放净冷却水(加注防冻液的柴油发电机除外)。平日要经常性做好柴油发电机的保养工作,使机器始终保持在良好的技术状态运转。要勤观察、勤检查,发现故障,及时排除。
1. Use: that is, use the diesel generator correctly. Before starting, shake the vehicle first to make the lubricating parts such as bearing shells get lubricating oil before starting. After start-up, it shall be put into operation when the water temperature reaches 40-50 ℃. Overload or low-speed operation for a long time is strictly prohibited. Before shutdown, unload the load and reduce the speed. After shutdown in winter, drain the cooling water when the water temperature drops to 40-50 ℃ (except for diesel generators filled with antifreeze). The diesel generator shall be maintained regularly on weekdays to keep the machine in good technical condition. Observe and check frequently, and eliminate faults in time.
2、磨:即磨合。这是延长柴油发电机使用寿命的基础。无论是新的还是大修后的柴油发电机,都必须按规范进行磨合后,方能投入正常作业。
2. Grinding: namely running in. This is the basis for prolonging the service life of diesel generator. New or overhauled diesel generators must be run in according to the specifications before they can be put into normal operation.
瓦斯发电机组
3、检:即经常检查紧固部位。因康明斯柴油发电机组在使用过程中受震动冲击和负荷不均等影响,螺栓、螺母容易松动。还有各部位的调整螺栓都要仔细检查,以免造成因松动而损坏机件的事故。
3. Inspection: check the fastening parts frequently. Because Cummins diesel generator set is affected by vibration impact and uneven load during use, bolts and nuts are easy to loosen. In addition, the adjusting bolts of all parts should be carefully checked to avoid the accident of loosening and damaging the parts.
4、含有大量尘土,将会加速缸套、活塞和活塞环的磨损。若冷却水不,会使冷却系水垢增加,妨碍柴油发电机散热,润滑条件变差,机件磨损严重。若机体外表不净,会使机体表面受到腐蚀,缩短使用寿命。
4. It contains a lot of dust, which will accelerate the wear of cylinder liner, piston and piston ring. If the cooling water is not, it will increase the scale of the cooling system, hinder the heat dissipation of the diesel generator, worsen the lubrication conditions and seriously wear the parts. If the body surface is not clean, the body surface will be corroded and the service life will be shortened.
5、足:即油足、水足、空气足。若柴、柴油和空气供应不及时或中断,就会出现起动困难、400KW柴油发电机价格燃烧不良、柴油发电机功率功率下降、柴油发电机不能正常运转等现象。若机油供不应求或中断,会使柴油发电机润滑不良、柴油发电机机件磨损严重甚至出现烧瓦现象。若冷却水不足,会使机温过高,功率下降,磨损加剧,降低使用寿命。
5. Sufficient: sufficient oil, water and air. If the supply of diesel, diesel and air is not timely or interrupted, there will be difficulties in starting, poor combustion of 400KW diesel generator price, reduction of diesel generator power, failure of diesel generator to operate normally, etc. If the oil supply is in short supply or interrupted, the diesel generator will have poor lubrication, serious wear of diesel generator parts, and even Bush burning. If the cooling water is insufficient, the machine temperature will be too high, the power will be reduced, the wear will be intensified, and the service life will be reduced.
7、调:即康明斯柴油发电机组的气门间隙、配气相位、供油提前角、喷油压力以及点火正时等都应及时检查并调整,以柴油发电机经常处于良好的技术状态,方能节省燃油,延长使用寿命。
7. Adjustment: the valve clearance, valve timing, fuel supply advance angle, fuel injection pressure and ignition timing of Cummins diesel generator set shall be checked and adjusted in time, so that the diesel generator is often in good technical condition, so as to save fuel and prolong service life.
以上就是今天小编给大家提供的精彩内容,更多的精彩内容请点击进入我们的官方网站:瓦斯发电机组http://www.huannengpower.com
The above is the wonderful content provided by Xiaobian today. For more wonderful content, please click to enter our official website: gas generator set http://www.huannengpower.com
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

延长柴油发电机长寿秘诀有哪些?

1、用:即正确使用柴油发电机。起动前,应先摇车,使各轴瓦等润滑部位得到润滑油后再起动。起动后,应待水温达到40-50℃时,再投人作业。严禁长时间超负荷或低速作业。停机前,应先卸掉负荷,降低转速。冬季停车后,应待水温下降至40-50℃时,放净冷却水(加注防冻液的柴油发电机除外)。平日要经常性做好柴油发电机的保养工作,使机器始终保持在良好的技术状态运转。要勤观察、勤检查,发现故障,及时排除。
1. Use: that is, use the diesel generator correctly. Before starting, shake the vehicle first to make the lubricating parts such as bearing shells get lubricating oil before starting. After start-up, it shall be put into operation when the water temperature reaches 40-50 ℃. Overload or low-speed operation for a long time is strictly prohibited. Before shutdown, unload the load and reduce the speed. After shutdown in winter, drain the cooling water when the water temperature drops to 40-50 ℃ (except for diesel generators filled with antifreeze). The diesel generator shall be maintained regularly on weekdays to keep the machine in good technical condition. Observe and check frequently, and eliminate faults in time.
2、磨:即磨合。这是延长柴油发电机使用寿命的基础。无论是新的还是大修后的柴油发电机,都必须按规范进行磨合后,方能投入正常作业。
2. Grinding: namely running in. This is the basis for prolonging the service life of diesel generator. New or overhauled diesel generators must be run in according to the specifications before they can be put into normal operation.
瓦斯发电机组
3、检:即经常检查紧固部位。因康明斯柴油发电机组在使用过程中受震动冲击和负荷不均等影响,螺栓、螺母容易松动。还有各部位的调整螺栓都要仔细检查,以免造成因松动而损坏机件的事故。
3. Inspection: check the fastening parts frequently. Because Cummins diesel generator set is affected by vibration impact and uneven load during use, bolts and nuts are easy to loosen. In addition, the adjusting bolts of all parts should be carefully checked to avoid the accident of loosening and damaging the parts.
4、含有大量尘土,将会加速缸套、活塞和活塞环的磨损。若冷却水不,会使冷却系水垢增加,妨碍柴油发电机散热,润滑条件变差,机件磨损严重。若机体外表不净,会使机体表面受到腐蚀,缩短使用寿命。
4. It contains a lot of dust, which will accelerate the wear of cylinder liner, piston and piston ring. If the cooling water is not, it will increase the scale of the cooling system, hinder the heat dissipation of the diesel generator, worsen the lubrication conditions and seriously wear the parts. If the body surface is not clean, the body surface will be corroded and the service life will be shortened.
5、足:即油足、水足、空气足。若柴、柴油和空气供应不及时或中断,就会出现起动困难、400KW柴油发电机价格燃烧不良、柴油发电机功率功率下降、柴油发电机不能正常运转等现象。若机油供不应求或中断,会使柴油发电机润滑不良、柴油发电机机件磨损严重甚至出现烧瓦现象。若冷却水不足,会使机温过高,功率下降,磨损加剧,降低使用寿命。
5. Sufficient: sufficient oil, water and air. If the supply of diesel, diesel and air is not timely or interrupted, there will be difficulties in starting, poor combustion of 400KW diesel generator price, reduction of diesel generator power, failure of diesel generator to operate normally, etc. If the oil supply is in short supply or interrupted, the diesel generator will have poor lubrication, serious wear of diesel generator parts, and even Bush burning. If the cooling water is insufficient, the machine temperature will be too high, the power will be reduced, the wear will be intensified, and the service life will be reduced.
7、调:即康明斯柴油发电机组的气门间隙、配气相位、供油提前角、喷油压力以及点火正时等都应及时检查并调整,以柴油发电机经常处于良好的技术状态,方能节省燃油,延长使用寿命。
7. Adjustment: the valve clearance, valve timing, fuel supply advance angle, fuel injection pressure and ignition timing of Cummins diesel generator set shall be checked and adjusted in time, so that the diesel generator is often in good technical condition, so as to save fuel and prolong service life.
以上就是今天小编给大家提供的精彩内容,更多的精彩内容请点击进入我们的官方网站:瓦斯发电机组http://www.huannengpower.com
The above is the wonderful content provided by Xiaobian today. For more wonderful content, please click to enter our official website: gas generator set http://www.huannengpower.com