欢迎进入济南济柴环能燃气发电设备有限公司官网!
当前位置:首页 - 新闻中心 - 行业资讯

行业资讯

瓦斯发电机组使用步骤中要注意哪些地方

返回 2022.12.27 来源:http://www.huannengpower.com 0
瓦斯发电机组在使用程序中要严格按照使用教程去操作,保证发电机组各项作业运行正常,那么瓦斯发电机组使用步骤中要注意哪些地方?
The gas generator set shall be operated in strict accordance with the use tutorial in the use procedure to ensure the normal operation of each operation of the generator set. What should be paid attention to in the use procedure of the gas generator set?
瓦斯发电机组应严格按瓦斯发电机组操作程序,使用清洗、呈碱性的清洁的软化水做冷却水,以免气缸盖水腔内沉积水垢、泥沙等污物,影响冷却效果,甚至造成气缸盖裂痕。应通过验查与调节气门间隙,领悟、柴油机维修掌握各气缸进、排气门的损伤、下陷情况。
The gas generator set shall strictly follow the operating procedures of the gas generator set, and use clean and alkaline softened water as cooling water to prevent scale, sediment and other contaminants from depositing in the cylinder head water cavity, affecting the cooling effect and even causing cylinder head cracks. Check and adjust the valve clearance to understand the damage and depression of the inlet and exhaust valves of each cylinder through diesel engine maintenance.
低温环境下启动发电机组时,要先将发电机组冷却水和机油加热至20℃以上。另外,瓦斯发电机组启动前应人力盘转主轴12周,无异样状况后方可起动。使用过程中怠速运转时间不宣过长。
When starting the generator set in low temperature environment, first heat the cooling water and oil of the generator set to above 20 ℃. In addition, before starting the gas generator unit, the main shaft shall be rotated manually for 12 weeks, and it can be started only after there is no abnormal condition. Idle running time is not too long during use.
因为发电机组长久低温怠速运转时,机油会产生一种胶状物附着在气门与气门导管壁上,使气门运动受阻,停车后气门往往被粘住,此时若再起动发电机组,气门系统就要出事故。这种现象在气温低或机油质量较差时易出现。
Because when the generator set operates at low temperature and idle speed for a long time, the engine oil will produce a kind of glue attached to the valve and the valve guide wall, which will block the valve movement. The valve is often stuck after stopping. At this time, if the generator set is started again, the valve system will have an accident. This phenomenon is easy to occur when the temperature is low or the oil quality is poor.
瓦斯发电机组
瓦斯发电机组有缸盖罩壳,进行检查:如个别汽缸工作异常或刚修理、更换过汽缸盖,也应打开缸盖罩壳,进行验看,作业正常的汽缸通常无需此项察看。
The gas generator set has a cylinder head cover for inspection: if individual cylinders are abnormal or have just been repaired or replaced, the cylinder head cover should also be opened for inspection. Normally, cylinders that operate normally do not need this inspection.
瓦斯发电机组发电机组起动前预供油时,打开气缸盖上罩壳,观察摇臂衬套处是否有机油流出。若发现不上油时,应立即拆检。观察缸盖下罩壳内机油积存量的大小,正常时不应有积存,如有,说明缸盖回油道堵塞,应及时清理,保持回油道畅通。具体可验看:瓦斯发电机组对气体的要求以及运行指南。
When the gas generator set is pre supplied with oil before starting, open the upper cover of the cylinder head and observe whether there is oil flowing out at the rocker arm bushing. If no oil is found, it shall be immediately disassembled for inspection. Observe the size of the oil accumulation in the lower cover of the cylinder head. Normally, there should be no oil accumulation. If there is, it means that the oil return passage of the cylinder head is blocked. It should be cleaned in time to keep the oil return passage unblocked. Specific check: gas requirements and operation guide of gas generator set.
瓦斯发电机组的维保也很重要,只有对发电机组的维护和维护到位,发电机组才能很好的正常作业。更多相关事项就来关注我们网站http://www.huannengpower.com咨询吧!
The maintenance of gas generator set is also very important. Only when the maintenance of generator set is in place, can the generator set operate normally. Follow our website for more relevant matters http://www.huannengpower.com Consult!
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

瓦斯发电机组使用步骤中要注意哪些地方

瓦斯发电机组在使用程序中要严格按照使用教程去操作,保证发电机组各项作业运行正常,那么瓦斯发电机组使用步骤中要注意哪些地方?
The gas generator set shall be operated in strict accordance with the use tutorial in the use procedure to ensure the normal operation of each operation of the generator set. What should be paid attention to in the use procedure of the gas generator set?
瓦斯发电机组应严格按瓦斯发电机组操作程序,使用清洗、呈碱性的清洁的软化水做冷却水,以免气缸盖水腔内沉积水垢、泥沙等污物,影响冷却效果,甚至造成气缸盖裂痕。应通过验查与调节气门间隙,领悟、柴油机维修掌握各气缸进、排气门的损伤、下陷情况。
The gas generator set shall strictly follow the operating procedures of the gas generator set, and use clean and alkaline softened water as cooling water to prevent scale, sediment and other contaminants from depositing in the cylinder head water cavity, affecting the cooling effect and even causing cylinder head cracks. Check and adjust the valve clearance to understand the damage and depression of the inlet and exhaust valves of each cylinder through diesel engine maintenance.
低温环境下启动发电机组时,要先将发电机组冷却水和机油加热至20℃以上。另外,瓦斯发电机组启动前应人力盘转主轴12周,无异样状况后方可起动。使用过程中怠速运转时间不宣过长。
When starting the generator set in low temperature environment, first heat the cooling water and oil of the generator set to above 20 ℃. In addition, before starting the gas generator unit, the main shaft shall be rotated manually for 12 weeks, and it can be started only after there is no abnormal condition. Idle running time is not too long during use.
因为发电机组长久低温怠速运转时,机油会产生一种胶状物附着在气门与气门导管壁上,使气门运动受阻,停车后气门往往被粘住,此时若再起动发电机组,气门系统就要出事故。这种现象在气温低或机油质量较差时易出现。
Because when the generator set operates at low temperature and idle speed for a long time, the engine oil will produce a kind of glue attached to the valve and the valve guide wall, which will block the valve movement. The valve is often stuck after stopping. At this time, if the generator set is started again, the valve system will have an accident. This phenomenon is easy to occur when the temperature is low or the oil quality is poor.
瓦斯发电机组
瓦斯发电机组有缸盖罩壳,进行检查:如个别汽缸工作异常或刚修理、更换过汽缸盖,也应打开缸盖罩壳,进行验看,作业正常的汽缸通常无需此项察看。
The gas generator set has a cylinder head cover for inspection: if individual cylinders are abnormal or have just been repaired or replaced, the cylinder head cover should also be opened for inspection. Normally, cylinders that operate normally do not need this inspection.
瓦斯发电机组发电机组起动前预供油时,打开气缸盖上罩壳,观察摇臂衬套处是否有机油流出。若发现不上油时,应立即拆检。观察缸盖下罩壳内机油积存量的大小,正常时不应有积存,如有,说明缸盖回油道堵塞,应及时清理,保持回油道畅通。具体可验看:瓦斯发电机组对气体的要求以及运行指南。
When the gas generator set is pre supplied with oil before starting, open the upper cover of the cylinder head and observe whether there is oil flowing out at the rocker arm bushing. If no oil is found, it shall be immediately disassembled for inspection. Observe the size of the oil accumulation in the lower cover of the cylinder head. Normally, there should be no oil accumulation. If there is, it means that the oil return passage of the cylinder head is blocked. It should be cleaned in time to keep the oil return passage unblocked. Specific check: gas requirements and operation guide of gas generator set.
瓦斯发电机组的维保也很重要,只有对发电机组的维护和维护到位,发电机组才能很好的正常作业。更多相关事项就来关注我们网站http://www.huannengpower.com咨询吧!
The maintenance of gas generator set is also very important. Only when the maintenance of generator set is in place, can the generator set operate normally. Follow our website for more relevant matters http://www.huannengpower.com Consult!