欢迎进入济南济柴环能燃气发电设备有限公司官网!
当前位置:首页 - 新闻中心 - 行业资讯

行业资讯

通常沼气发电机启动困难怎么检查

返回 2022.11.30 来源:http://www.huannengpower.com 0
沼气发电机组启动困难出现该故障,应检查混合器是否有沼气进入沼气发电机组,沼气供给系统是否有故障,检查混合气是否符合质和量的要求。等等,具体步骤如下:
If the fault occurs due to difficult startup, check whether there is biogas entering the biogas generator set in the mixer, whether there is any fault in the biogas supply system, and whether the mixture meets the quality and quantity requirements. The specific steps are as follows:
1)检查沼气装置或电路是否有故障,ECU电源打开后,减压器电磁阀应有喀哒响声。
1) Check whether the biogas device or circuit is faulty. After the ECU power is turned on, the solenoid valve of the pressure reducer should make a clicking sound.
2)检查12V继电器是否良好。
2) Check whether the 12V relay is in good condition.
3)检查沼气管路是否畅通,阀门是否开启。
3) Check whether the biogas pipeline is unblocked and whether the valve is open.
4)检查钢瓶是否有气。
4) Check the cylinder for air.
5)检查混合气浓度是否过浓或过稀,调整混合器上的怠速浓度调整螺钉,顺时针混合气加浓,反时针混合气变稀,或加或取一张混合器膜片铜垫片。加铜垫片混合气变稀,减铜垫片混合气变浓。
5) Check whether the mixture concentration is too rich or too thin, adjust the idle concentration adjusting screw on the mixer, increase the mixture concentration clockwise, and decrease the mixture concentration counterclockwise, or add or take a copper diaphragm gasket of the mixer. The mixture of copper gasket is diluted, and the mixture of copper gasket is enriched.
沼气发电机组
6)检查高压线跳火性能,检查高压线是否漏电。
6) Check the flashover performance of the high-voltage line and check whether the high-voltage line leaks electricity.
7)检查线束插接件是否可靠。
7) Check whether the harness connector is reliable.
8)检查曲轴转角信号传感器是否良好。
8) Check whether the crankshaft angle signal sensor is in good condition.
9)检查整车电源及电压变换器输出电压是否符合要求。
9) Check whether the vehicle power supply and voltage converter output voltage meet the requirements.
10)检查蓄电瓶电压是否过低、连接是否正常。
10) Check whether the battery voltage is too low and the connection is normal.
11)检查火花塞电间隙是否正常,有无积炭。
11) Check whether the spark plug electric gap is normal and whether there is carbon deposit.
12)检查空气滤清器是否良好,进气管路是否畅通。
12) Check whether the air filter is in good condition and whether the air inlet pipe is unblocked.
13)检查起动机是否工作正常。
13) Check whether the starter works normally.
14)检查ECU是否工作正常。
14) Check whether the ECU works normally.
通常沼气发电机启动困难怎么检查?我们可以通过14个要点了解起来,更多相关内容就来我们网站http://www.huannengpower.com咨询吧!
How to check the starting difficulty of biogas generator? We can learn about it through 14 points, and more relevant content will come to our website http://www.huannengpower.com Consult!
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

通常沼气发电机启动困难怎么检查

沼气发电机组启动困难出现该故障,应检查混合器是否有沼气进入沼气发电机组,沼气供给系统是否有故障,检查混合气是否符合质和量的要求。等等,具体步骤如下:
If the fault occurs due to difficult startup, check whether there is biogas entering the biogas generator set in the mixer, whether there is any fault in the biogas supply system, and whether the mixture meets the quality and quantity requirements. The specific steps are as follows:
1)检查沼气装置或电路是否有故障,ECU电源打开后,减压器电磁阀应有喀哒响声。
1) Check whether the biogas device or circuit is faulty. After the ECU power is turned on, the solenoid valve of the pressure reducer should make a clicking sound.
2)检查12V继电器是否良好。
2) Check whether the 12V relay is in good condition.
3)检查沼气管路是否畅通,阀门是否开启。
3) Check whether the biogas pipeline is unblocked and whether the valve is open.
4)检查钢瓶是否有气。
4) Check the cylinder for air.
5)检查混合气浓度是否过浓或过稀,调整混合器上的怠速浓度调整螺钉,顺时针混合气加浓,反时针混合气变稀,或加或取一张混合器膜片铜垫片。加铜垫片混合气变稀,减铜垫片混合气变浓。
5) Check whether the mixture concentration is too rich or too thin, adjust the idle concentration adjusting screw on the mixer, increase the mixture concentration clockwise, and decrease the mixture concentration counterclockwise, or add or take a copper diaphragm gasket of the mixer. The mixture of copper gasket is diluted, and the mixture of copper gasket is enriched.
沼气发电机组
6)检查高压线跳火性能,检查高压线是否漏电。
6) Check the flashover performance of the high-voltage line and check whether the high-voltage line leaks electricity.
7)检查线束插接件是否可靠。
7) Check whether the harness connector is reliable.
8)检查曲轴转角信号传感器是否良好。
8) Check whether the crankshaft angle signal sensor is in good condition.
9)检查整车电源及电压变换器输出电压是否符合要求。
9) Check whether the vehicle power supply and voltage converter output voltage meet the requirements.
10)检查蓄电瓶电压是否过低、连接是否正常。
10) Check whether the battery voltage is too low and the connection is normal.
11)检查火花塞电间隙是否正常,有无积炭。
11) Check whether the spark plug electric gap is normal and whether there is carbon deposit.
12)检查空气滤清器是否良好,进气管路是否畅通。
12) Check whether the air filter is in good condition and whether the air inlet pipe is unblocked.
13)检查起动机是否工作正常。
13) Check whether the starter works normally.
14)检查ECU是否工作正常。
14) Check whether the ECU works normally.
通常沼气发电机启动困难怎么检查?我们可以通过14个要点了解起来,更多相关内容就来我们网站http://www.huannengpower.com咨询吧!
How to check the starting difficulty of biogas generator? We can learn about it through 14 points, and more relevant content will come to our website http://www.huannengpower.com Consult!