你好,欢迎来到济南济柴环能燃气发电设备有限公司官方网站!

沼气发电机在运行中一定要遵守的点

来源:http://www.huannengpower.com   发布于:2019-03-29

沼气脱硫脱水一定要做好,务必运用高效工业型脱硫剂,并且要及时改换。目前市面上好的氧化铁脱硫剂,其硫容都在15%左右。处置养殖场沼气,脱硫剂运用寿命在1500小时左右,到期必需改换。

Dehydration and desulfurization of biogas must be done well, high-efficiency industrial desulfurizer must be used and changed in time. At present, the sulfur capacity of the best iron oxide desulfurizer on the market is about 15%. The life of desulfurizer is about 1500 hours for the disposal of biogas from farms, and it must be changed when it expires.

2.务必运用沼气发起机专用油,专用油比普通油粘度高,并且能够吸收沼气中的硫,这样能够有效避免涡轮增压器轴的腐蚀。

2. Make sure to use special oil for biogas engine. The special oil has higher viscosity than ordinary oil and can absorb sulfur in biogas. This can effectively avoid the corrosion of turbocharger shaft.

3.机油改换周期不得超越400小时。即便是专用油,若不按时改换,油质粘度降低,变脏,会招致涡轮增压器过油不畅,终在高转速下会加速磨损。

3. The oil replacement cycle shall not exceed 400 hours. Even if the special oil is not changed on time, the oil viscosity decreases and becomes dirty, which will cause the turbocharger to overshoot and eventually accelerate wear and tear at high speed.

4.每次开机后,不要马上合闸带负载。由于机油循环到涡轮增压器需求一定时间。在机油还没有到增压器油管时,忽然加负载,同样会招致增压器的轴,页片等因短少光滑而磨损。

QQ截图20171025151837.jpg

4. Do not close the load immediately after each boot-up. It takes a certain time for the oil to circulate to the turbocharger. When the oil has not arrived at the supercharger tubing, the sudden load will also cause the supercharger shaft, sheets and so on to wear and tear because of the short and smooth.

当听到自然气发电机组在滚动进程中泛起不正常的响声时,首先要肯定响声是来自何处沼气发电机组,例如是气门室内部、机体内部、前盖板处、发电机与柴油机的接合处还是汽缸内。当肯定部位后,就要依照柴油机的工作原理中止断定。

When hearing the abnormal noise of natural gas generator set in rolling process, first of all, we should make sure where the noise comes from, such as valve chamber, body interior, front cover, generator-diesel engine junction or cylinder. When the position is confirmed, the determination should be discontinued according to the working principle of the diesel engine.

当听到异常响声在机体内部时,应疾速停机,翻开柴油机的机体侧盖板,用手推进连杆的中间位置,假定响声在连杆的上部,此时能够判别是活塞与连杆铜套泛起缺陷。假定在闲逛的进程中发现响声在连杆的下部,则能够判别是连杆与轴颈的间隙过年夜或曲轴自身有缺陷。

When abnormal noise is heard inside the body, the engine should be shut down quickly, the side cover of the diesel engine should be opened, the middle position of the connecting rod should be pushed by hand, assuming that the noise is on the upper part of the connecting rod, then the defect of the piston and the copper sleeve of the connecting rod can be distinguished. Assuming that the sound is found at the lower part of the connecting rod in the course of loitering, it can be distinguished that the gap between the connecting rod and the journal is too large or that the crankshaft itself is defective.

沼气发电机组置办留意事项由我们为您解答,沼气发电机组分为自然气发电机组高浓度沼气发电机组和低浓度沼气发电机组两种,低浓度沼气发电机组主要合用于瓦斯浓度在25%以下的气体,高浓度则合用于瓦斯浓度在25%以上的气体。

Notes for setting up biogas generating units will be answered by us. The biogas generating units are divided into two types: high-concentration biogas generating units and low-concentration biogas generating units. Low-concentration biogas generating units are mainly used for gases with gas concentration below 25%, while high-concentration biogas generating units are used for gases with gas concentration above 25%.

瓦斯主要指是甲烷(cH4)是无色无味无嗅可燃起的气体,爆炸前提浓度在5至16%,氧气大于12%,遇明火或者温度650至750,就惹起爆炸,浓度9.5%爆炸才干大。

Gas mainly refers to methane (cH4) is a colorless, odorless, odorless and ignitable gas. Before explosion, the concentration is 5-16%, oxygen is more than 12%. When open fire or temperature is 650-750, it will cause explosion, and the concentration is 9.5%.

瓦斯发电不但具有可观的经济效益,又能够有效预防瓦斯事故的发作,保证煤矿工作的平安性,也因而国度积极推行瓦斯发电项目。

Gas power generation not only has considerable economic benefits, but also can effectively prevent the occurrence of gas accidents and ensure the safety of coal mine work. Therefore, the country actively promotes gas power generation projects.

本文的精彩内容由沼气发电机组进行编写,本公司坚持以诚信合作的共赢理念,为您提供完善的服务,欢迎点击进入:http://www.huannengpower.com

The excellent content of this article is compiled by biogas generating units. Our company adheres to the win-win concept of honesty and cooperation, and provides you with perfect service. Welcome to http://www.huannengpower.com.


上一篇:沼气发电机组工作执行的标准
下一篇:选择沼气内燃发电机组选择参考的条件有哪些?