你好,欢迎来到济南济柴环能燃气发电设备有限公司官方网站!

内燃式焦炉煤气发电机组的性能介绍

来源:http://www.huannengpower.com   发布于:2017-10-26

1焦炉煤气内燃机发电机组在组成内部局域供电网络后,在总配电室低压总开关处安装并网同期装置一套,通过同期装置和市电低压并网后可供企业内部使用。
1 coke oven gas engine generator sets in the composition of the internal local power supply network, the total power distribution room low-voltage main switch installation synchronization device and a synchronization device and power through the low voltage grid available for internal use.
2在总配电室低压总开关处安装逆功率保护模块一套,可防止外网停电时发电机所发电力反送入市电电网造成事故。
2 install a reverse power protection module at the low voltage main switch of the main distribution room, which can prevent the power generated by the generator from being sent back to the power grid when the external network is blackout.
3当外网停电时,低压总开关通过逆功率模块控制断路器跳开,发电机变成孤网运行,保证风机、循环氨水泵等主要设备不断电而正常运行;可避免焦炉因停风机而产生的烟火污染,如功率足够大也可保证焦炉的正常生产。

QQ截图20171025151941.jpg3 when the external power failure, low voltage switch through the inverse power module control circuit breaker tripping into isolated operation of generator, ensure the main equipment of fan, circulating ammonia pump constant electric and normal operation can be avoided; because coke oven fan stop caused by fireworks pollution, such as power can also be large enough to ensure the normal production of the coke oven.
4当外网再次供电时,可通过总开关处同期装置再次并网继续运行。
4, when the external network power supply again, through the main switch at the same time again connected to the grid continue to run.
5发电机组可通过程控机软件实时监控发电机组的各种温度、压力、电压、电流等参数和自动调节煤气、冷却水等流量,保证发电机组的正常运行
The 5 generator can control the temperature, pressure, voltage, current and other parameters of the generator set automatically and adjust the flow of gas and cooling water to ensure the normal operation of the generator set through the process control software
对于焦化企业来讲,任何时间停电都将造成巨大的损失,一旦停电,焦炉上升管因压力过高,焦炉荒煤气逸出,均需打开放散管放散而造成焦炉炉顶浓烟滚滚,环保方面是不允许的。
For the coking enterprises, any power outage will cause huge loss, once the power tube, due to excessive pressure of coke oven coke oven gas rise, escape, are required to open the powder tube caused by smoke billowing from coke oven top emission, environmental protection is not allowed.
另外由于焦炉炉体内荒煤气无法导出,压力过高会造成内部串漏对炉体的损害也很大,循环氨水停止循环也会给煤气冷却和焦油导出造成极大困难;由此可见,采用双回路不间断供电对企业来讲是至关重要的。
In addition the coke oven in the waste gas can not be exported, high pressure will cause internal leakage on the furnace body damage is also great, stop circulating ammonia circulation will cause great difficulties for gas cooling and tar derived; thus, using double loop uninterruptible power supply is crucial for enterprises.

上一篇:瓦斯发电机组机油冷却器简介
下一篇:燃气发电机组安装中应该避免的过程