欢迎进入济南济柴环能燃气发电设备有限公司官网!

常见问题解答

燃气发电机组的使用有什么要求

返回 2022.08.08 来源:http://www.huannengpower.com 0
近年来,随着社会的发展,人们对环保的意识也在不断地提高。燃气发电机组作为一种环保性比较强的发电机组深受人们的喜爱。燃气发电机组在使用时有什么要求呢?
In recent years, with the development of society, people's awareness of environmental protection is constantly improving. As a kind of generator set with strong environmental protection, gas generator set is deeply loved by people. What are the requirements for the gas generator set in use?
燃气发电机组使用燃气的要求
Requirements for the use of gas for gas-fired generating units
燃气发电机组的燃料以沼气为主,也可以使用油田伴生气、液化石油气、燃气等可燃性气体。所用的气体应通过干燥脱水,达到无游离水、原油和轻质油,其低热值不应低于31.4mj/m3,总硫含量不大于480mg/m3,硫化氢含量不大于20mg/m3.此外燃气输送压力在0.08-0.30MAP范围内。
The fuel of the gas-fired power generation unit is mainly biogas, and combustible gases such as oil field associated gas, liquefied petroleum gas and gas can also be used. The gas used shall be dried and dewatered to be free of free water, crude oil and light oil. Its low calorific value shall not be less than 31.4mj/m3, total sulfur content shall not be greater than 480mg / m3, and hydrogen sulfide content shall not be greater than 20mg / m3. In addition, the gas transmission pressure shall be within the range of 0.08-0.30map.
燃气发电机组使用冷却液
Coolant used for gas generator set
用于冷却系统的直接冷却发动机的冷却液通常使用清洁的淡水,雨水或经澄清的河水为宜。当燃气发电机组在低于0度的环境条件使用时,应严防冷却液冻结,致使零件冻裂。可根据温度来配用适当凝点的防冻液或在起动前加注热水,但停车后应立即放水。
Clean fresh water, rain water or clarified river water are usually used as the coolant for the direct cooling engine of the cooling system. When the gas-fired generator set is used under the environmental conditions below 0 ℃, the cooling liquid shall be strictly prevented from freezing and causing parts to freeze. Antifreeze with proper freezing point can be added according to the temperature or hot water can be added before starting, but water shall be drained immediately after shutdown.
燃气发电机组
燃气发电机组所用的机油
Oil for gas generator set
燃气发电机组的运动件并对这些运动件起到冷却散热、带走杂质和防止锈的作用。其品质的好坏除对燃气发电机组的性能和使用寿命有影响外,对机油的使用期限有一定的影响。为此,应根据燃气发电机组的使用环境温度来选适当的机油。
The moving parts of the gas generator set play the role of cooling and heat dissipation, removing impurities and preventing rust. The quality of the oil not only affects the performance and service life of the gas generator set, but also has a certain impact on the service life of the oil. Therefore, the proper oil shall be selected according to the operating environment temperature of the gas generator set.
此外发电机组的燃气在使用前,应经过预处理(如过滤、气液分离、稳压等)。温度过高时,还应采用冷却器冷却,以保证燃气中没有液态成分。针对不同燃气,处理的流程也不同。若气源压力不足,发电机组虽能正常启动,但可能达不到标定功率。所以用户在选购机组前,应提供气体成分和压力,以便公司提供适宜的产品。
In addition, the gas of the generator set shall be pretreated before use (such as filtration, gas-liquid separation, pressure stabilization, etc.). When the temperature is too high, the cooler shall also be used for cooling to ensure that there is no liquid component in the gas. The treatment process is different for different gas. If the air source pressure is insufficient, the generator set can be started normally, but it may not reach the rated power. Therefore, before purchasing the unit, the user should provide the gas composition and pressure so that the company can provide appropriate products.
以上就是小编介绍燃气发电机组对燃气等方面的因素做的相关要求,您有需求购买或者安装使用的话就来我们网站http://www.huannengpower.com咨询了解看看吧。
The above is the relevant requirements of the gas generator set for gas and other factors. If you need to purchase or install, please come to our website http://www.huannengpower.com Consult and understand.
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

燃气发电机组的使用有什么要求

近年来,随着社会的发展,人们对环保的意识也在不断地提高。燃气发电机组作为一种环保性比较强的发电机组深受人们的喜爱。燃气发电机组在使用时有什么要求呢?
In recent years, with the development of society, people's awareness of environmental protection is constantly improving. As a kind of generator set with strong environmental protection, gas generator set is deeply loved by people. What are the requirements for the gas generator set in use?
燃气发电机组使用燃气的要求
Requirements for the use of gas for gas-fired generating units
燃气发电机组的燃料以沼气为主,也可以使用油田伴生气、液化石油气、燃气等可燃性气体。所用的气体应通过干燥脱水,达到无游离水、原油和轻质油,其低热值不应低于31.4mj/m3,总硫含量不大于480mg/m3,硫化氢含量不大于20mg/m3.此外燃气输送压力在0.08-0.30MAP范围内。
The fuel of the gas-fired power generation unit is mainly biogas, and combustible gases such as oil field associated gas, liquefied petroleum gas and gas can also be used. The gas used shall be dried and dewatered to be free of free water, crude oil and light oil. Its low calorific value shall not be less than 31.4mj/m3, total sulfur content shall not be greater than 480mg / m3, and hydrogen sulfide content shall not be greater than 20mg / m3. In addition, the gas transmission pressure shall be within the range of 0.08-0.30map.
燃气发电机组使用冷却液
Coolant used for gas generator set
用于冷却系统的直接冷却发动机的冷却液通常使用清洁的淡水,雨水或经澄清的河水为宜。当燃气发电机组在低于0度的环境条件使用时,应严防冷却液冻结,致使零件冻裂。可根据温度来配用适当凝点的防冻液或在起动前加注热水,但停车后应立即放水。
Clean fresh water, rain water or clarified river water are usually used as the coolant for the direct cooling engine of the cooling system. When the gas-fired generator set is used under the environmental conditions below 0 ℃, the cooling liquid shall be strictly prevented from freezing and causing parts to freeze. Antifreeze with proper freezing point can be added according to the temperature or hot water can be added before starting, but water shall be drained immediately after shutdown.
燃气发电机组
燃气发电机组所用的机油
Oil for gas generator set
燃气发电机组的运动件并对这些运动件起到冷却散热、带走杂质和防止锈的作用。其品质的好坏除对燃气发电机组的性能和使用寿命有影响外,对机油的使用期限有一定的影响。为此,应根据燃气发电机组的使用环境温度来选适当的机油。
The moving parts of the gas generator set play the role of cooling and heat dissipation, removing impurities and preventing rust. The quality of the oil not only affects the performance and service life of the gas generator set, but also has a certain impact on the service life of the oil. Therefore, the proper oil shall be selected according to the operating environment temperature of the gas generator set.
此外发电机组的燃气在使用前,应经过预处理(如过滤、气液分离、稳压等)。温度过高时,还应采用冷却器冷却,以保证燃气中没有液态成分。针对不同燃气,处理的流程也不同。若气源压力不足,发电机组虽能正常启动,但可能达不到标定功率。所以用户在选购机组前,应提供气体成分和压力,以便公司提供适宜的产品。
In addition, the gas of the generator set shall be pretreated before use (such as filtration, gas-liquid separation, pressure stabilization, etc.). When the temperature is too high, the cooler shall also be used for cooling to ensure that there is no liquid component in the gas. The treatment process is different for different gas. If the air source pressure is insufficient, the generator set can be started normally, but it may not reach the rated power. Therefore, before purchasing the unit, the user should provide the gas composition and pressure so that the company can provide appropriate products.
以上就是小编介绍燃气发电机组对燃气等方面的因素做的相关要求,您有需求购买或者安装使用的话就来我们网站http://www.huannengpower.com咨询了解看看吧。
The above is the relevant requirements of the gas generator set for gas and other factors. If you need to purchase or install, please come to our website http://www.huannengpower.com Consult and understand.