欢迎进入济南济柴环能燃气发电设备有限公司官网!

常见问题解答

发电机组的正常操作流程

返回 2022.05.27 来源:http://www.huannengpower.com 0
开机启动准备工作
Preparation for startup
1、 检查发电机紧固件、连接件是否松动,活动部件是否灵活。
1. Check whether the fasteners and connecting pieces of the generator are loose and whether the moving parts are flexible.
2、 检查燃油、机油及冷却水的储量是否满足使用要求。
2. Check whether the reserves of fuel, engine oil and cooling water meet the use requirements.
3、 检查控制柜上的负载空气开关,应在断开位置,并将电压旋钮整定在电压更小的位置上。
3. Check that the load air switch on the control cabinet should be in the off position, and set the voltage knob to the minimum voltage position.
4、 焦化发电机组开机前的准备工作,严格按照使用操作说明书要求进行。
4. The preparation before startup of the coking generator unit shall be carried out in strict accordance with the requirements of the operation manual.
5、 必要时,通知供电部门拉下断路器开关,切断市电高压供电线路。
5. If necessary, inform the power supply department to pull down the circuit breaker switch and cut off the high-voltage power supply line of the mains.
启动步骤
Startup steps
1、空载启动焦化发电机组按使用说明规定的方法进行启动。
1. Start the coking generator unit without load according to the method specified in the instructions.
2、按柴油发电机的说明书要求调整转速和电压。
2. Adjust the speed and voltage according to the instructions of the diesel generator.
3、一切正常后,将负载开关切换至发电机端,按倒闸操作顺序,逐级合上负荷开关,使之进入工作供电状态。
3. After everything is normal, switch the load switch to the generator end, and close the load switch step by step according to the switching operation sequence to make it enter the working power supply state.
焦化发电机组
4、运行中时刻注意三相电流是否平衡,各电气仪表指示是否正常。
4. During operation, always pay attention to whether the three-phase current is balanced and whether the indication of each electrical instrument is normal.
运行注意事项
Operating precautions
1、 定时检查水位、油温及油压的变化情况,并做好记录。
1. Regularly check the changes of water level, oil temperature and oil pressure, and make records.
2、 出现漏油、漏水、漏气情况要及时修复,必要时停止发电机工作。
2. In case of oil, water and air leakage, it shall be repaired in time, and the generator shall be stopped if necessary.
发电机停机注意事项
Precautions for generator shutdown
1、 逐级切断负载,断开自动空气开关。
1. Cut off the load step by step and disconnect the automatic air switch.
2、 按照焦化发电机组配备的使用说明书进行停机。
2. Shut down according to the operating instructions provided for the coking generator unit.
3、 做好发电机的清洁卫生工作。
3. Clean the generator.
所以无论是安装还是日常检修维护,多要对发电机组有足够的重视。更多相关内容就来网站www.huannengpower.com咨询了解吧!
Therefore, whether it is installation or routine maintenance, it is necessary to pay enough attention to the generator set. For more information, please visit www.huannengpower Www. 68mn!
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

发电机组的正常操作流程

开机启动准备工作
Preparation for startup
1、 检查发电机紧固件、连接件是否松动,活动部件是否灵活。
1. Check whether the fasteners and connecting pieces of the generator are loose and whether the moving parts are flexible.
2、 检查燃油、机油及冷却水的储量是否满足使用要求。
2. Check whether the reserves of fuel, engine oil and cooling water meet the use requirements.
3、 检查控制柜上的负载空气开关,应在断开位置,并将电压旋钮整定在电压更小的位置上。
3. Check that the load air switch on the control cabinet should be in the off position, and set the voltage knob to the minimum voltage position.
4、 焦化发电机组开机前的准备工作,严格按照使用操作说明书要求进行。
4. The preparation before startup of the coking generator unit shall be carried out in strict accordance with the requirements of the operation manual.
5、 必要时,通知供电部门拉下断路器开关,切断市电高压供电线路。
5. If necessary, inform the power supply department to pull down the circuit breaker switch and cut off the high-voltage power supply line of the mains.
启动步骤
Startup steps
1、空载启动焦化发电机组按使用说明规定的方法进行启动。
1. Start the coking generator unit without load according to the method specified in the instructions.
2、按柴油发电机的说明书要求调整转速和电压。
2. Adjust the speed and voltage according to the instructions of the diesel generator.
3、一切正常后,将负载开关切换至发电机端,按倒闸操作顺序,逐级合上负荷开关,使之进入工作供电状态。
3. After everything is normal, switch the load switch to the generator end, and close the load switch step by step according to the switching operation sequence to make it enter the working power supply state.
焦化发电机组
4、运行中时刻注意三相电流是否平衡,各电气仪表指示是否正常。
4. During operation, always pay attention to whether the three-phase current is balanced and whether the indication of each electrical instrument is normal.
运行注意事项
Operating precautions
1、 定时检查水位、油温及油压的变化情况,并做好记录。
1. Regularly check the changes of water level, oil temperature and oil pressure, and make records.
2、 出现漏油、漏水、漏气情况要及时修复,必要时停止发电机工作。
2. In case of oil, water and air leakage, it shall be repaired in time, and the generator shall be stopped if necessary.
发电机停机注意事项
Precautions for generator shutdown
1、 逐级切断负载,断开自动空气开关。
1. Cut off the load step by step and disconnect the automatic air switch.
2、 按照焦化发电机组配备的使用说明书进行停机。
2. Shut down according to the operating instructions provided for the coking generator unit.
3、 做好发电机的清洁卫生工作。
3. Clean the generator.
所以无论是安装还是日常检修维护,多要对发电机组有足够的重视。更多相关内容就来网站www.huannengpower.com咨询了解吧!
Therefore, whether it is installation or routine maintenance, it is necessary to pay enough attention to the generator set. For more information, please visit www.huannengpower Www. 68mn!