欢迎进入济南济柴环能燃气发电设备有限公司官网!

常见问题解答

瓦斯发电机组长期不用再使用时要注意?

返回 2022.04.06 来源:http://www.huannengpower.com 0
  检查机房内是否有积水或温度过高,可能导致连接部件腐蚀、电路腐蚀、裂纹和发电机(电球)。由于腐蚀,所有仪器都没有进行敏感检查,并且目视检查瓦斯发电机组是否漏水、漏油和漏气。
  Check whether there is water in the equipment room or the temperature is too high, which may cause corrosion of connection components, circuit corrosion, cracks, and generators (electric spheres). Due to corrosion, all instruments were not sensitized and the gas generator set was visually checked for water leakage, oil leakage and air leakage.
  检查瓦斯机冷却水箱内冷却水是否充足,检查冷却水箱内节温器是否腐蚀。如果被腐蚀,则须更换或清洁。保持冷却水畅通,检查空气滤清器滤芯是否干净,无油污,是否可以更换或清洗。保持发动机进气口通畅,检查机油油位及质量(因长期粘度不足或未使用的机油变质,须补充或更换,检查油水分离器是否有水),如果有水,如果有水,油和水分离器须在水中浸泡很长时间才能更换。
  Check whether the cooling water in the cooling water box of the gas machine is sufficient and whether the thermostat in the cooling water box is corroded. If corroded, it must be replaced or cleaned. Keep the cooling water unblocked, check whether the air filter element is clean, no oil, whether it can be replaced or cleaned. Keep the engine air inlet unobblocked, check the oil level and quality (due to long-term lack of viscosity or unused oil deterioration, must be added or replaced, check whether there is water in the oil-water separator), if there is water, if there is water, oil and water separator must be soaked in water for a long time to replace.
  检查瓦斯储油箱内的瓦斯是否充足,连接管之间是否有漏油或松动的部位,检查瓦斯滤清器表面是否有杂质或水,必要时更换或清洗以确保有足够的燃料和机油。道路畅通,防止瓦斯发电机组组因缺油、油路堵塞、漏风而停止正常发电,避免不必要的麻烦和损失。
  Check whether the gas in the gas storage tank is sufficient, whether there is oil leakage or loose parts between the connecting pipes, check whether there are impurities or water on the surface of the gas filter, and replace or clean the gas filter if necessary to ensure that there is enough fuel and oil. Smooth road, prevent gas generator group due to lack of oil, oil road blockage, air leakage and stop normal power generation, avoid unnecessary trouble and loss.
  操作瓦斯发电机组设备前,用500V表测量发电机及控制系统各绕组对地绝缘电阻。在室温下不应小于2兆欧。如果绝缘电阻低于上述值,则须进行干燥。
  Before operating the equipment, use a 500V meter to measure the insulation resistance of the windings of the generator and control system to the ground. Should not be less than 2 megohm at room temperature. If the insulation resistance is lower than the above value, it must be dried.
  启动发电机组前,须关闭控制柜的开关。启动时间不超过15秒,间隔不低于2分钟。次启动后,高速运转3-5分钟,检查发动机是否漏水漏油,听瓦斯发电机组组各部件之间是否有异响,检查控制器上的参数值是否屏幕是否正常,是否有报警或警告提示,如果有警告提示,请按照警告内容进行故障排除。
  Before starting the generator set, turn off the switch of the control cabinet. The startup time is no more than 15 seconds and the interval is no less than 2 minutes. After starting for the first time, run at high speed for 3-5 minutes, check whether the engine leaks water, listen to whether there is abnormal sound between the components of the gas generator group, check whether the parameter values on the controller screen is normal, whether there is an alarm or warning prompt, if there is a warning prompt, please troubleshoot according to the warning content.
  瓦斯发电机组长期不用再使用时要注意什么?以上便是讲解内容,希望通过我们的分享可以帮助到大家,更多发电机组资讯关注www.huannengpower.com后期的更新。
  What should be paid attention to when gas generator set is no longer used for a long time? The above is to explain the content, I hope that through our sharing can help you, more generator set information to pay attention to www.huannengpower.com later update.
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

瓦斯发电机组长期不用再使用时要注意?

  检查机房内是否有积水或温度过高,可能导致连接部件腐蚀、电路腐蚀、裂纹和发电机(电球)。由于腐蚀,所有仪器都没有进行敏感检查,并且目视检查瓦斯发电机组是否漏水、漏油和漏气。
  Check whether there is water in the equipment room or the temperature is too high, which may cause corrosion of connection components, circuit corrosion, cracks, and generators (electric spheres). Due to corrosion, all instruments were not sensitized and the gas generator set was visually checked for water leakage, oil leakage and air leakage.
  检查瓦斯机冷却水箱内冷却水是否充足,检查冷却水箱内节温器是否腐蚀。如果被腐蚀,则须更换或清洁。保持冷却水畅通,检查空气滤清器滤芯是否干净,无油污,是否可以更换或清洗。保持发动机进气口通畅,检查机油油位及质量(因长期粘度不足或未使用的机油变质,须补充或更换,检查油水分离器是否有水),如果有水,如果有水,油和水分离器须在水中浸泡很长时间才能更换。
  Check whether the cooling water in the cooling water box of the gas machine is sufficient and whether the thermostat in the cooling water box is corroded. If corroded, it must be replaced or cleaned. Keep the cooling water unblocked, check whether the air filter element is clean, no oil, whether it can be replaced or cleaned. Keep the engine air inlet unobblocked, check the oil level and quality (due to long-term lack of viscosity or unused oil deterioration, must be added or replaced, check whether there is water in the oil-water separator), if there is water, if there is water, oil and water separator must be soaked in water for a long time to replace.
  检查瓦斯储油箱内的瓦斯是否充足,连接管之间是否有漏油或松动的部位,检查瓦斯滤清器表面是否有杂质或水,必要时更换或清洗以确保有足够的燃料和机油。道路畅通,防止瓦斯发电机组组因缺油、油路堵塞、漏风而停止正常发电,避免不必要的麻烦和损失。
  Check whether the gas in the gas storage tank is sufficient, whether there is oil leakage or loose parts between the connecting pipes, check whether there are impurities or water on the surface of the gas filter, and replace or clean the gas filter if necessary to ensure that there is enough fuel and oil. Smooth road, prevent gas generator group due to lack of oil, oil road blockage, air leakage and stop normal power generation, avoid unnecessary trouble and loss.
  操作瓦斯发电机组设备前,用500V表测量发电机及控制系统各绕组对地绝缘电阻。在室温下不应小于2兆欧。如果绝缘电阻低于上述值,则须进行干燥。
  Before operating the equipment, use a 500V meter to measure the insulation resistance of the windings of the generator and control system to the ground. Should not be less than 2 megohm at room temperature. If the insulation resistance is lower than the above value, it must be dried.
  启动发电机组前,须关闭控制柜的开关。启动时间不超过15秒,间隔不低于2分钟。次启动后,高速运转3-5分钟,检查发动机是否漏水漏油,听瓦斯发电机组组各部件之间是否有异响,检查控制器上的参数值是否屏幕是否正常,是否有报警或警告提示,如果有警告提示,请按照警告内容进行故障排除。
  Before starting the generator set, turn off the switch of the control cabinet. The startup time is no more than 15 seconds and the interval is no less than 2 minutes. After starting for the first time, run at high speed for 3-5 minutes, check whether the engine leaks water, listen to whether there is abnormal sound between the components of the gas generator group, check whether the parameter values on the controller screen is normal, whether there is an alarm or warning prompt, if there is a warning prompt, please troubleshoot according to the warning content.
  瓦斯发电机组长期不用再使用时要注意什么?以上便是讲解内容,希望通过我们的分享可以帮助到大家,更多发电机组资讯关注www.huannengpower.com后期的更新。
  What should be paid attention to when gas generator set is no longer used for a long time? The above is to explain the content, I hope that through our sharing can help you, more generator set information to pay attention to www.huannengpower.com later update.