During biogas power generation, the biogas fermentation environment must be controlled to ensure the efficiency and quality of power generation. Therefore, the following four aspects should be paid attention to when using biogas generator set:

刚采购过来的沼气发电机组，在运行了50个小时建议进行一次常规保养，因为机组的磨合期的保养至关重要，操作人员必须经常检查沼气发电机组进气管路，防止沼气泄漏和冷凝水过多而影响供气。

For the newly purchased biogas generator set, it is recommended to carry out a routine maintenance after 50 hours of operation, because the maintenance of the unit during the running in period is very important. The operator must often check the air inlet pipeline of the biogas generator set to prevent biogas leakage and too much condensate from affecting the gas supply.

沼气发电机工作时应经常巡视检查沼气发电机组的运行情况，沼气脱硫及稳压防爆装置，另外，为了防止进气管回火引起沼气管路发生爆炸，应在沼气供应管路上安置防回火与防爆装置，发现问题应及时调整或上报有关领导。

During the operation of the biogas generator, the operation of the biogas generator unit and the biogas desulfurization, pressure stabilization and explosion-proof devices shall be inspected frequently. In addition, in order to prevent the explosion of the biogas pipeline caused by the tempering of the air inlet pipe, the anti tempering and explosion-proof devices shall be installed on the biogas supply pipeline, and the problems found shall be adjusted or reported to the relevant leaders in time.

进气系统：沼气发电机在运行中，操作人员应随时掌握负载变化情况并应对沼气发电机的负荷进行限制，在进气总管上，需加装一套沼气一空气混合器，以调节空燃比和混合气进气量。

Air inlet system: during the operation of biogas generator, the operator shall keep abreast of the load changes and limit the maximum load of biogas generator. A set of biogas air mixer shall be installed on the main air inlet pipe to adjust the air-fuel ratio and air intake of mixed gas.

发动机：沼气的燃烧速度很慢，所以对沼气发动机有较高的要求。沼气发电机的过滤装置应定期清洗。

Engine: the combustion speed of biogas is very slow, so there are high requirements for biogas engine. The filter device of biogas generator shall be cleaned regularly.

调速系统：沼气发电机组沼气进气压力不得低于1.8kPa，沼气发动机的运行场合是和发电机一起以用电设备为负荷进行运转，为了确保发电机正常发电，沼气发动机上的调速系统必不可少。

Speed regulation system: the biogas inlet pressure of biogas generator set shall not be less than 1.8kpa. The operation occasion of biogas engine is to operate with the generator under the load of electrical equipment. In order to ensure the normal power generation of generator, the speed regulation system on biogas engine is essential.

以上就是沼气发电机组为您提供的今日内容分享，更多的精彩内容请点击我们的网站http://www.huannengpower.com我们后续会有更多的内容为您呈现.

The above is today's content sharing provided by biogas generator set. For more wonderful content, please click our website http://www.huannengpower.com We will have more content for you later