Before the biogas generator set is put into normal use, it shall be debugged to ensure the normal operation of the unit and reduce the occurrence of unit failure. The following describes the test and detection methods and precautions of full power biogas generator set of China's biogas generator set manufacturers.

　　沼气发电机组制造商

　　Biogas generator set manufacturer

　　1.检查沼气发电机组外观是否清洁;如果地脚螺母、飞轮螺钉等运动部件的螺母有松动迹象，本发明要求在有松动迹象时实时紧固。

　　1. Check whether the appearance of biogas generator set is clean; if the nuts of moving parts such as foundation nuts and flywheel screws show signs of loosening, the invention requires to tighten them in real time when there are signs of loosening.

　　2.沼气发电机组各缸减压状态下,迁移改变曲轴检查各缸声音作品相同的戒指,曲轴的迁移转变,与此同时,油泵进入摩擦表面,然后打开救援机构,摇动曲轴,raid生成器可以气缸漏气,如果摇动曲轴时,觉得很困难,并示意紧缩是正常的。

　　2. When each cylinder of the biogas generator set is under pressure reduction, the crankshaft shall be moved and changed. Check the ring with the same sound works of each cylinder. At the same time, the oil pump enters the friction surface, then open the rescue mechanism, shake the crankshaft, and the raid generator can leak air in the cylinder. If it is difficult to shake the crankshaft, and indicate that tightening is normal.

　　3.检查沼气发电机组的局部间隙是否准确，尤其要仔细检查各进、排气阀的间隙。

　　3. Check whether the local clearance of biogas generator set is accurate, especially the clearance of each inlet and exhaust valve.

　　4.检查沼气发电机组燃料供应系统情况，步骤如下:

　　4. Check the fuel supply system of biogas generator set, the steps are as follows:

　　1)检查沼气发电机组燃料箱盖上的通风孔是否畅通，如有污物进入孔内，应及时清洗。参与柴油可以满足商标的要求，油量可以丰富，并打开油路开关。

　　1) Check whether the vent hole on the fuel tank cover of the biogas generator set is unblocked. If there is dirt entering the vent hole, clean it in time. Participating in the diesel can meet the requirements of the trademark, the fuel quantity can be rich, and the oil circuit switch can be turned on.

　　2)翻转沼气发电机组的泄压机构，转动曲轴，各缸应有响亮的注油声，说明注油良好。如果没有听到注油的声音，可能是由于沼气发生器油回路中的大气引起的。此时可松开柴油滤清器排气螺杆及喷射泵，清理油路内的大气。

　　2) Turn over the pressure relief mechanism of the biogas generator set, rotate the crankshaft, and each cylinder shall have a loud oil injection sound, indicating that the oil injection is good. If no oil filling sound is heard, it may be caused by the atmosphere in the oil circuit of biogas generator. At this time, loosen the diesel filter exhaust screw and injection pump to clean the air in the oil circuit.

　　3)检查油管是否有漏油迹象，并及时处理。

　　3) Check the oil pipe for signs of oil leakage, and deal with it in time.

　　以上是沼气发电机组制造商全力公司向用户介绍的沼气发电机组出厂前的检测方法，希望以上的介绍能给用户提供参考。

　　The above is the test method of biogas generator set before leaving factory introduced by the manufacturer of biogas generator set to the user. I hope the above introduction can provide reference for the user.