你好,欢迎来到济南济柴环能燃气发电设备有限公司官方网站!

柴油发电机组漏油漏水漏气怎么办

来源:http://www.huannengpower.com   发布于:2017-02-25

  当柴油发电机组出现漏油、漏水、漏气现象时,会导致油料消耗增加,加速零件磨损,功率下降等等故障。因此一定要及时修复。以下是柴油发电机组出现漏油、漏水、漏气现象时处理方法:

  When the diesel generator set oil leakage, leakage, leakage phenomenon, will lead to increased oil consumption, accelerate the wear parts, power failure and so on. So be sure to repair in time. The following is the treatment of diesel generator sets oil leakage, leakage, leakage phenomenon:

  1、加垫治漏法

  1, add pad governance leakage method

  柴油发电机组油管接头防漏垫圈处漏油,可在防漏垫圈的两侧加一层双面光滑的薄塑料垫,用力拧紧即可防漏。

  The oil of diesel generator tubing joint gasket, with a thin plastic pad a layer of double smooth on both sides of the gasket, then tighten the leak.

  2、漆片液治漏法

  2, coating liquid leakage method

  柴油发电机组油箱、水箱、曲轴箱等接缝处渗漏,可将漆片放在酒精里浸泡之后,把漆片液涂抹在清洗干净的接缝处即可治漏。但漆片成本高,一般在情况紧急时才使用。

  Oil tank, water tank, diesel generator crankshaft box joint leakage, can be done to soak in alcohol, paint smear at the seams can be cleaned leakage. But the paint cost is high, only use in an emergency.

  3、以油治漏法

  3, the oil treatment method

  柴油发电机组的油底壳、气缸盖、齿轮室盖、曲轴箱后盖等处的纸垫渗漏时,只要纸垫完好,接合面清洁,便可在纸垫两面抹上一层黄油,拧紧螺栓即可防漏。如果换用新纸垫,安装前要将新纸垫在柴油中浸泡10分钟,然后取出擦净,在接合面抹一层黄油后再装上。

  Diesel generator oil leakage at the end of paper pad shell, cylinder cover, gear chamber cover, crankcase cover and other department, as long as the paper pad intact, joint surface cleaning, can be a layer of butter in the rub on the pad of paper, tighten the bolts can leak. If you use a new paper pad, before installing the new paper pad to soak in the diesel oil for 10 minutes, and then remove the clean, in the joint surface of a layer of butter and then loaded.

  4、液态密封胶治漏法

  4, liquid sealant leakage method

  柴油发电机组上出现固体垫圈缺陷(如坑凹、沟槽、破裂)而形成界面性渗漏和破坏性渗漏时,用液态密封胶涂抹在清洗干净的固体垫圈结合面上,固化后可形成均匀、稳定、连续黏附的可剥性薄膜垫圈,可防治一切渗漏现象。

  Solid washer diesel generator on the defects (such as pit, trench, rupture) formed interface leakage and destructive leakage when applied in solid gasket clean on the joint surface with liquid sealant, after curing can form uniform and stable, continuous adhesion of strippable film washers, can prevent all leakage.

  5、厌氧胶治漏法

  5, anaerobic glue treatment method

  柴油发电机组上的通气螺栓、双头螺栓、螺堵等处出现渗漏时,用厌氧胶涂抹在清洗干净的螺栓、螺纹或螺孔处,能很快固化形成薄膜,填充零件空隙,并能承受较大压力,同时还具有防震性强和防松的紧固功能。如用于柴油发电机组高压油管接头螺纹处,治漏效果更好。

  Leaking diesel generator on the ventilation of the bolt, stud bolt, screw plug etc, with anaerobic adhesive coated in the bolt, screw or screw hole clean, fast curing film forming, filling the part void, and can withstand greater pressure, but also has a strong anti shock and loose fastening function. Such as the use of diesel generator sets of high pressure oil pipe joint thread, the effect of better governance leakage.

  6、尺寸恢复胶治漏法

  In 6, the size of the restoration of rubber governance leakage method

  柴油发电机组上的轴与轴套、轴承与轴承座、阀与阀座、自紧油封、毛毡杯和盘根填料等处渗漏时,可用尺寸恢复胶涂抹在清洗干净的配合件磨损部位上,等固化后,就形成了耐磨、耐热、机械强度较高的薄膜层,然后再进行车、镗、刮、锉等机械加工,恢复零件的几何形状和配合精度,从而解决渗漏问题。

  The diesel generator on the shaft and the shaft sleeve, the bearing and the bearing seat, the valve and valve seat, self tight seal, and packing etc. the cup felt leakage, available size plastic coated with recovery of clean parts wear parts, etc. after curing, formed a thin layer heat and abrasion resistance, high mechanical strength then, turning, boring, scraping, filing and other mechanical processing, restore the part geometry and the matching accuracy, so as to solve the leakage problem.

  7、黏补胶治漏法

  7, the method of sticking to glue

  柴油发电机组上的机体零件,如油箱、水箱、油管、水管等处的砂眼、气孔引起渗漏时,用黏补胶涂抹在清洗干净的破损处,即可收到治漏的效果。

  Diesel generator on body parts, such as oil tank, water tank, oil pipe, water pipe etc. the blisters, pores cause leakage, with sticky glue onto clean breakage, leakage resistant effect can be received.

  创造优良的产品,是我们的一惯追求,长期以来公司以高质量的产品和优良的服务赢得了国内外客户的信任。

  The creation of good products, is our pursuit of a long time, the company with high quality products and excellent service to win the trust of customers at home and abroad.


上一篇:柴油发电机组异常熄火原因
下一篇:柴油发电机组为什么要接地