你好,欢迎来到济南济柴环能燃气发电设备有限公司官方网站!

柴油发电机组使用注意事项

来源:http://www.huannengpower.com   发布于:2016-12-19

  柴油发电机组也属于机械设备,不管什么设备在使用前需要详细的了解设备的工作状态及知识,所以在操作前需要看产品使用说明书,结合说明来操作就会更加快速的掌握,但是说一句实话需要把那么厚的书本看完确实需要一定的耐心和毅力,其实一般书本上面有很多的都是理论的知识,只需要了解就行了,一些操作的常识是需要熟练掌握的,因为这个会直接影响到你自身的操作,下面我们就把柴油发电机组在使用中需要注意的事项给大家说一下:

  Diesel generator also belongs to the mechanical equipment, working condition and knowledge no matter what equipment before use requires detailed understanding of the equipment, so the need to look at the product instructions before operation, with instructions to operate will master more quickly, but to tell the truth to the thick book reading requires some patience and perseverance to do in fact, there are a lot of books in general are theoretical knowledge, only need to know on the line, some common sense is to master, because this will directly affect your own operation, we put the items under the diesel generator needs to pay attention in the use of to tell you:

  1、用户在第一次使用机器前还是需要大致的看一下使用说明书以及保养手册进行大致的了解。

  1, the user in the first use of the machine before or need to look at the use manual and maintenance manual for general understanding.

  2、机组在第一次运行50小时后需要对机器进行第一次的保养,也就是首保,保养包括机油,机油滤清器,柴油滤清器等。

  2, the unit in the first run 50 hours after the need for the first time the machine maintenance, that is, the first insurance, maintenance including oil, oil filters, diesel filters, etc.

  3、柴油发电机组应该在通风良好的环境下运行,避免废气和烟雾在操作间内不能排出,还有通风不畅会造成机器的温升。

  3, diesel generator set should run in a well ventilated environment, to avoid exhaust gas and smoke in the operating room can not be discharged, as well as poor ventilation will cause the machine temperature rise.

  4、请在给水箱加水时选择软水或者防冻液,当环境温度低于5℃时,应换成防冻液,或者放干净水箱、缸体内和机油冷却器内的水。

  4, please choose soft water or antifreeze in to the tank water, when the environment temperature is below 5 DEG C, should be replaced by antifreeze, or put a clean water tank, cylinder and oil cooler in the water.

  5、往柴油机内加燃油和机油时,需要选用规定牌号并采用专用的清洁容器。燃油需要经过沉淀72小时后加入油箱,在加入油箱时需要有滤网过滤。

  5, to the diesel engine with fuel and oil, the need to use the provisions of the brand and the use of special cleaning containers. The fuel needs to be added to the tank after 72 hours of settling.

  6、禁止无空气滤清器的情况下使用,防止空间未经过过滤进入汽缸。

  6, prohibit the use of no air filter to prevent space without filtering into the cylinder.

  7、启动前需要检查机油位,水位,以及电气连接线有无松动。

  7, before starting to check the oil level and water level, and the electrical connection line is loose.

  8、柴油发电机组在冷机启动后不能立马就转高速,需要怠速运行一会然后在转到高速运转,这样也有利于机械的磨合,切记不要长时间空转。

  8, diesel generator set in cold start can not immediately turn to high speed, idle running for a while and then go to the high-speed operation, this is also conducive to the machine running, remember not long time idling.

  9、柴油发电机组额功率需要按照标定的功率运行不能超过,超过会造成设备的损坏。

  9, diesel generator set power required in accordance with the rated power operation can not exceed, more than will cause equipment damage.

  10、机器在运行过程中,需要间隔一段时间就需要在机器旁边转一圈,首页是听机器的工作状态是否正常有无异响,其次是需要检查水位,以及发电电压和频率的参数是否有变化。

  10, the machine in the operation process, need after a period of time will need to turn a circle in the side of the machine, the home page is listening to the working state of the machine is normal with abnormal sound, followed by the need to check the water level, and the parameters of the power voltage and frequency is changing.

  11、停机后,长时间不使用需要卸掉电瓶线。

  11, shutdown, long time no need to remove the battery line.

  以上就是在正常使用柴油发电机组中需要注意的一些事项,机械设备需要经常性的观察运行状态以及使用情况,所以有些是必须需要做的,希望引起大家的注意,做好这些可以有效的减少柴油发电机组的使用故障率,降低使用成本,提高使用效率。

  Some of the issues above is the need to pay attention to in the normal use of diesel generator, mechanical equipment need to observe the operation status and regular usage, so there is need to do, hope to attract everyone's attention, do these failures can effectively reduce the diesel generator set rate, reduce the use of cost, improve the efficiency of the use of.


上一篇:沼气发电机组的使用性能及特点
下一篇:燃气发电机组的发动机的起动注意事项