你好,欢迎来到济南济柴环能燃气发电设备有限公司官方网站!

沼气发电机所需要的气柜的类型介绍

来源:http://www.huannengpower.com   发布于:2019-06-18

1.沼气发电机双膜气柜

1. Biogas Generator Double Membrane Gasholder

双层膜气柜外型为3/4球体,由钢轨固定于水泥基座或厌氧罐罐顶上。主体由特殊加工聚酯材质(主要成分为红泥软体复合膜及红泥软软体夹网布)制成,罐体由外膜、内膜、底膜(地上柜)及隶属设备组成,具有抗紫外线及各种微生物的才能,高度防火并契合规范。

The double-layer membrane gas holder is 3/4 sphere in shape, and is fixed on the cement base or the top of the anaerobic tank by the rail. The main body is made of specially processed polyester material (mainly composed of red mud soft composite film and red mud soft sandwich mesh cloth). The tank body is composed of outer membrane, inner membrane, bottom membrane (overground cabinet) and subordinate equipment. It has the ability of anti-ultraviolet radiation and various microorganisms. It is highly fireproof and conforms to the specifications.

内膜与底膜(地上柜)之间构成一个容量可变的气密空间用作贮存沼气,外膜构成贮存柜的球状外型。应用外膜进气鼓风机恒压,当内膜沼气量减少时,外膜经过鼓风机进气,坚持内膜沼气的设计压力,当沼气量增加时,内膜正常伸张,经过平安阀将外膜多余空气排出,使沼气压力一直恒定在一个需求的设计压力。可调理膜式沼气储气柜的保温原理:在内外膜之间充入空气,能有效阻挠外界冷空气进入。

An air-tight space with variable capacity is formed between the inner membrane and the bottom membrane (overground cabinet) for biogas storage, and the outer membrane forms a spherical shape of the storage cabinet. When the amount of methane in the inner membrane decreases, the outer membrane enters through the blower, and adheres to the design pressure of the inner membrane methane. When the amount of methane increases, the inner membrane expands normally, and the excess air in the outer membrane is discharged through the safety valve, so that the methane pressure remains constant at the design pressure required. Thermal insulation principle of adjustable membrane biogas storage tank: filling air between inner and outer membranes can effectively prevent the cold air from entering.

具有以下优势

It has the following advantages

1平安系数高

1. High safety factor

此产品十分平安牢靠, 5年以上的运用实积. 包括冰冷的德国、挪威, 中东的以色列, 极热的撒哈拉沙漠地域以致地震频繁的日本!完整契合/优于各国相关的法规及行业请求。设有过压平安阀及沼气走漏报警器。整个气柜在工厂内制造及测试终了, 保证质量没有导轨, 没有升降活塞,没有压重, 没有维修!气柜没有水封/油封/弹簧, 不怕结冰, 不须加温,不须调整! 不会产生负压而惹起塌顶、倒塌,完整可完成无人操作不产生污染, 没有如湿式气柜一样产生大量含酚废水, 形成二次污染 .

QQ截图20171025151846.jpg

This product is very safe and reliable. It has been used for more than five years. It includes cold Germany, Norway, Israel in the Middle East, and Japan with frequent earthquakes in the extremely hot Sahara Desert. It fully meets/surpasses the relevant laws and regulations of various countries and industry requests. It is equipped with over-pressure safety valve and methane leakage alarm. The whole gas holder is manufactured and tested in the factory. There is no guide rail, no lifting piston, no pressure, no maintenance! There is no water seal/oil seal/spring in the gas holder, no ice, no heating, no adjustment! There is no negative pressure to cause roof collapse, collapse, complete and unmanned operation without pollution, no phenolic wastewater like the wet gas holder, forming two. Secondary pollution.

2运用寿命长

2. Long service life

内层膜运用寿命25年以上外层膜运用寿命20年以上。

The service life of inner layer is more than 25 years, and that of outer layer is more than 20 years.

3装置便当快捷

3. Installation convenience

只需根本水泥基座, 数天时间即可完成装置, 俭省装置费用及时间 (例子: 2个5,000 M3 气柜于10天内装置完成!) 装置完成后可立即投入运用

The installation can be completed in only a few days with the basic cement base. The cost and time of the installation can be saved (example: 2 5,000 M3 gas holders are completed in 10 days). The installation can be put into operation immediately after completion.

4节约本钱

4. Save cost

柜内容量能够全部应用, 没有死区,整体气柜重量不大于5吨,大大简化及俭省基座的土建费用。(1000m3传统干式/湿式气柜仅仅钢材即重30吨以上, 没有湿式气柜所须的大型水槽) 造价较传统干式或湿式气柜更廉价。

Cabinet content can be fully applied, no dead zone, the overall weight of the gas tank is not more than 5 tons, greatly simplifying and saving the cost of civil construction of the base. (1000m3 traditional dry/wet gas holder weighs more than 30 tons of steel only, without the large water tank required for wet gas holder) the cost is cheaper than traditional dry or wet gas holder.

2.沼气发电机水封气柜

2. Water-sealed gas holder of biogas generator

3.沼气发电机干式气柜

3. Dry gas holder of biogas generator

沼气发电机所需求的进气压力为5-20KPA.

The required intake pressure of biogas generator is 5-20KPA.

沼气发电机的余热应用:沼气发电机的余热应用分为两局部;一是排烟温度余热应用,二是沼气发电机本身冷却热量应用.

The application of waste heat of biogas generator: the application of waste heat of biogas generator can be divided into two parts: one is the application of waste heat of exhaust gas temperature, the other is the application of cooling heat of biogas generator itself.

感谢您的阅读,此文的文章来源:沼气发电机组更多的内容和问题请点击:http://www.huannengpower.com   我们会继续努力的为您提供服务,感谢您的支持!

Thank you for reading, this article source: more content and questions of biogas generating units, please click: http://www.huannengpower.com, we will continue to work hard to provide you with services, thank you for your support!


上一篇:在日常的使用中怎么使用发电机组才能安全?
下一篇:燃气发电机在生产时需要注意哪一点?