你好,欢迎来到济南济柴环能燃气发电设备有限公司官方网站!

燃气发电机组启动前应注意

来源:http://www.huannengpower.com   发布于:2017-05-05

燃气发电机组和柴油发电机组一样,在操作使用时都需要注意一些事项,只有注意这些事项才能好的利用燃气发电机组为人工作。

Gas generating set and diesel generating sets, as are some matters need attention during operation, only pay attention to these matters can good use work for gas generator. 

一、每周启动发电机前应检查发电机的润滑油油位、两水箱的冷却液液位,禁止低油位、低冷却液位运行燃气发电机,以免损坏发电机,如润滑油液位低于下刻线,请及时加注润滑油,冷却液即加满为主,在运行停机后,待机温降下来时,请檫掉发电机机身的油污,以免时间长了难以处理,影响美观。

A, weekly check before start generator generator, two oil tank of the coolant fluid level, it is prohibited to low oil level, low gas generator cooling liquid level operation, in order to avoid damage to the generator, such as lubricating oil level below the scribed line, please refill lubricating oil, cooling fluid that is filled with primarily, after running down, standby temperature is lowered, please rub off the generator body oil, in order to avoid long handle hard, affect beautiful. 

燃气发电机组

二、如遇接到停电通知时,请提前一天测试燃气发电机组运行状态,确保停电时正常运行。

In case of a power failure, please test the gas generator set up a day in advance to ensure that the power failure is normal. 

启机步骤如下:

The steps are as follows: 

1、检查燃气气压力、润滑油油位、两水箱的冷却液液位,

Check the gas pressure, the lubricating oil level, the cooling liquid level of the two tanks, 

2、燃气发电机组将发电机有自动状态转换至手动状态;将万能转换开关由3点方向左旋转至12点方向为手动状态;

2, the gas generator sets the automatic state of the generator to the manual state. Switch the universal switch from 3 to 12 in a manual state. 

3、断开左下方发电机断路器;将断路器手柄扳至下方极为断开;

Disconnect the generator circuit breaker from the bottom left. Pull the breaker handle to the bottom and break it. 

4、启动发电机;将万能转换开关由12点方向向左旋转至6点方向即为点火启动机器;

4, start the generator; Switch the universal switch from 12 to 6 in the direction of ignition and start the machine. 

5、机器启动运行后请仔细关注电压400V,频率50HZ,转速1500转,运行10分钟待水温上升至60℃时,将万能转换开关由6点方向旋转至9点方向即为待机运行状态,5分钟后机器会自动停机;

After 5, the machine is up and running, please carefully focus voltage 400 v, 50 hz frequency, speed 1500 RPM, run 10 minutes for water temperature rise to 60 ℃, the universal switch direction by 6 to 9 o 'clock is the standby status, after 5 minutes the machine will automatically stop; 

6、燃气发电机组测试结束后,请回复断路器合闸状态,将万能转换开关由沼气发电机组9点方向旋转至3点方向,待停电时会自动启机 。

6, gas generating set after the test, please reply the breaker closing state, the universal switch by biogas generator set direction to 3 o 'clock, 9 o 'clock to automatically start the blackout. 

  以上就是小编为您讲解的有关知识,我们拥有严谨的工作态度,熟练的工作技能,将确保任务准确、高效的完成。

Above is the knowledge about small make up for your explanation. We have the rigorous work attitude, skilled jobs skills, will ensure that tasks are completed accurate and efficient. 


上一篇:沼气发电机组与燃气发电机组的区别
下一篇:沼气发电机组进气方式