欢迎进入济南济柴环能燃气发电设备有限公司官网!
当前位置:首页 - 新闻中心 - 发电机知识

发电机知识

沼气发电机组怎么保养才算是合格的?

返回 2021.03.05 来源:http://www.huannengpower.com 0
1、滤清器:①空气滤清器:每运转50小时,以空压机口吹气清理一次。每运行500小时或当警示装置呈红色时更换,更换滤芯后按顶端按钮将指示器重定;②机油滤清器:磨合期过后必须更换,以后每500小时或半年更换一次。更换滤清器后再开机运行10分钟,更换机油滤清器同时必须更换润滑油;③柴油滤清器:磨合期过后必须更换,以后每500小时或半年更换一次。更换滤清器后再开机运行10分钟;④冷却液滤清器:使用200小时或三个月必须更换。以后每500小时或一年更换一次。
1. Filter: ① air filter: clean it by blowing air from the air compressor port every 50 hours. Replace every 500 hours of operation or when the warning device is red, press the top button to reset the indicator after replacing the filter element; ② oil filter: it must be replaced after the running in period, and then every 500 hours or half a year. After the filter is replaced, the engine should be turned on for 10 minutes, and the lubricating oil must be replaced at the same time when the oil filter is replaced; ③ the diesel filter must be replaced after the running in period, and then every 500 hours or half a year. (4) coolant filter: it must be replaced if it is used for 200 hours or three months for the first time. It will be replaced every 500 hours or once a year.
2、润滑油的更换:磨合期过后必须更换,以后每500小时或每半年更换一次。更换机油时不同品牌、不同型号的机油不得混合使用。更换润滑油时必须更换机油滤清器。
沼气发电机组
2. Replacement of lubricating oil: it must be replaced after the running in period, and then every 500 hours or half a year. When changing engine oil, different brands and models of engine oil shall not be mixed. The oil filter must be changed when changing the lubricating oil.
3、冷却液的更换:使用200小时或三个月必须更换。以后每500小时或一年更换一次。注意刚停机机组,15分钟内切不可打开水箱盖。防止水蒸气喷出伤人。
3. Change of coolant: it must be changed after first use for 200 hours or three months. It will be replaced every 500 hours or once a year. Pay attention to the unit just shut down. Do not open the water tank cover within 15 minutes. Prevent water vapor from spraying out and injuring people.
4、每日例行或开机前检查事项:检查并排除漏油、漏水、漏气的三漏现象,擦拭发电机组表面,保持柴油机外观及环境整洁;保持机组整机清洁度。防止积存水质,铁质和杂物;检查燃油箱油位。保证机组的应急供电;检查机油液面高度,是否有不正常增高或下降,并查明原因,不足时及时添加;检查水箱水位;检查电池电压,注意加蒸馏水;检查各保护罩的松动情况及各连接部件螺丝、螺母紧固;进入冬季应注意保温,并在水箱内注入足够防冻液。
4. Daily routine or pre startup inspection items: check and eliminate the three leakage phenomena of oil leakage, water leakage and air leakage, wipe the surface of the generator set, keep the appearance and environment of the diesel engine clean and tidy, and keep the whole unit clean. Prevent the accumulation of water, iron and debris; check the fuel tank level. Ensure the emergency power supply of the unit; check the oil level, whether there is abnormal increase or decrease, and find out the reasons, and add it in time when it is insufficient; check the water level of the water tank; check the battery voltage, pay attention to adding distilled water; check the looseness of the protective cover and the fastening of the screws and nuts of the connecting parts; pay attention to heat preservation in winter, and inject enough antifreeze into the water tank.
5、沼气发电机组运行测试保养:L燃料箱需每星期彻底清理一次,以防止积存水质,铁质和杂质;对于备用沼气发电机组,每周启动一次试运转操作,检视仪表盘指示灯,空载运行5分钟,每半个月带适量负载运行15-30分钟;水箱皮带之松紧度每周检查一次,如有磨损,应更换。
5. Operation test and maintenance of biogas generator set: l fuel tank shall be cleaned thoroughly once a week to prevent water quality, iron and impurities from accumulating; for standby biogas generator set, start test operation once a week, check indicator light of instrument panel, run no-load for 5 minutes, and run with appropriate load for 15-30 minutes every half a month; tightness of water tank belt shall be checked once a week, if there is any wear If it is damaged, it should be replaced.
新闻搜索
济南济柴环能燃气发电设备有限公司
  • 服务热线

    0531-62325028
    0531-69951266

沼气发电机组怎么保养才算是合格的?

1、滤清器:①空气滤清器:每运转50小时,以空压机口吹气清理一次。每运行500小时或当警示装置呈红色时更换,更换滤芯后按顶端按钮将指示器重定;②机油滤清器:磨合期过后必须更换,以后每500小时或半年更换一次。更换滤清器后再开机运行10分钟,更换机油滤清器同时必须更换润滑油;③柴油滤清器:磨合期过后必须更换,以后每500小时或半年更换一次。更换滤清器后再开机运行10分钟;④冷却液滤清器:使用200小时或三个月必须更换。以后每500小时或一年更换一次。
1. Filter: ① air filter: clean it by blowing air from the air compressor port every 50 hours. Replace every 500 hours of operation or when the warning device is red, press the top button to reset the indicator after replacing the filter element; ② oil filter: it must be replaced after the running in period, and then every 500 hours or half a year. After the filter is replaced, the engine should be turned on for 10 minutes, and the lubricating oil must be replaced at the same time when the oil filter is replaced; ③ the diesel filter must be replaced after the running in period, and then every 500 hours or half a year. (4) coolant filter: it must be replaced if it is used for 200 hours or three months for the first time. It will be replaced every 500 hours or once a year.
2、润滑油的更换:磨合期过后必须更换,以后每500小时或每半年更换一次。更换机油时不同品牌、不同型号的机油不得混合使用。更换润滑油时必须更换机油滤清器。
沼气发电机组
2. Replacement of lubricating oil: it must be replaced after the running in period, and then every 500 hours or half a year. When changing engine oil, different brands and models of engine oil shall not be mixed. The oil filter must be changed when changing the lubricating oil.
3、冷却液的更换:使用200小时或三个月必须更换。以后每500小时或一年更换一次。注意刚停机机组,15分钟内切不可打开水箱盖。防止水蒸气喷出伤人。
3. Change of coolant: it must be changed after first use for 200 hours or three months. It will be replaced every 500 hours or once a year. Pay attention to the unit just shut down. Do not open the water tank cover within 15 minutes. Prevent water vapor from spraying out and injuring people.
4、每日例行或开机前检查事项:检查并排除漏油、漏水、漏气的三漏现象,擦拭发电机组表面,保持柴油机外观及环境整洁;保持机组整机清洁度。防止积存水质,铁质和杂物;检查燃油箱油位。保证机组的应急供电;检查机油液面高度,是否有不正常增高或下降,并查明原因,不足时及时添加;检查水箱水位;检查电池电压,注意加蒸馏水;检查各保护罩的松动情况及各连接部件螺丝、螺母紧固;进入冬季应注意保温,并在水箱内注入足够防冻液。
4. Daily routine or pre startup inspection items: check and eliminate the three leakage phenomena of oil leakage, water leakage and air leakage, wipe the surface of the generator set, keep the appearance and environment of the diesel engine clean and tidy, and keep the whole unit clean. Prevent the accumulation of water, iron and debris; check the fuel tank level. Ensure the emergency power supply of the unit; check the oil level, whether there is abnormal increase or decrease, and find out the reasons, and add it in time when it is insufficient; check the water level of the water tank; check the battery voltage, pay attention to adding distilled water; check the looseness of the protective cover and the fastening of the screws and nuts of the connecting parts; pay attention to heat preservation in winter, and inject enough antifreeze into the water tank.
5、沼气发电机组运行测试保养:L燃料箱需每星期彻底清理一次,以防止积存水质,铁质和杂质;对于备用沼气发电机组,每周启动一次试运转操作,检视仪表盘指示灯,空载运行5分钟,每半个月带适量负载运行15-30分钟;水箱皮带之松紧度每周检查一次,如有磨损,应更换。
5. Operation test and maintenance of biogas generator set: l fuel tank shall be cleaned thoroughly once a week to prevent water quality, iron and impurities from accumulating; for standby biogas generator set, start test operation once a week, check indicator light of instrument panel, run no-load for 5 minutes, and run with appropriate load for 15-30 minutes every half a month; tightness of water tank belt shall be checked once a week, if there is any wear If it is damaged, it should be replaced.